Heatless Air Dryer
Get Price Quote
A Heatless Air Dryer consist of two towers, which, alternately cycle on drying and regeneration. Each tower is filled with a bed of adsorbent desiccant. When one tower is on drying cycle, the desiccant adsorbs moisture from the incoming wet air stream and the other tower is on a regenerating cycle, which, a small portion of the super dried air passing through the desiccant to pick up and remove the adsorbed moisture, which is then vented to atmosphere. The towers are alternated in such a manner so that Dry desiccant is always in contact with wet compressed air, resulting in a continuous supply of Dry Air downstream. The process is automatically reversed from one tower to another by a microprocessor based sequenced timer. Dryer must be protected against water and oil suspended in the form of drops or finely dispersed mist. If the risk for such condition exists, a high efficiency pre-filter must be installed before the dryer. In regular course a ceramic candle Pre-filter is installed prior to the dryer to take care of incoming dust, dirt and foreign particles. By default, a ceramic candle After-filter is installed after the dryer to take care of desiccant dust carry forward in the dry air. The Pearl make heatless dryer is capable of providing a -40°C or lower atmospheric dew point and features a non-lubricated 3-way pneumatic switching valve. The operation is fully automatic and continuous without attention. Features: Pressure equalization: ensures dry air supply is continuous and at constant pressure. Electronic Timer: Highly precise and fail-safe with excellent repeatability Low Dew Point: Constant atmospheric dew point of - 40°C or below. Instant dry air availability: Easy to install & operate, requiring very few, low-cost spares. Low Power Consumption: Approximately 50 Watts only. Equipped with Silencers: low noise level.
Drytech Refrigerated Air Dryer
39,000 Per Piece
1 Piece (MOQ)
Best Deals from Compressed Air Dryer
Refrigerated Air Dryer
100,000 Per Piece
1 Piece (MOQ)
We are offering Refrigerated Air Dryer having air capacity of typically above 500 NM3/ hr for lager air drying capacities. It is a skid mounted unit consisting of air-Freon chiller air to air pre-cooler and a moisture separator. In this, first air is pre-cooled with outing chilled air at around 25°C and then it is cooled in a Freon cooler at (+)3°C temperature and hence reduces power consumption. Outgoing dry air has (+)3°C dew point and comes out at around 25°C temperature, as (+) 3°C Dew Point is equal to around (-) 25°C Atmospheric pressure Dewpoint. Dew Point: (-) 25°C is the best possible Dew Point achievable from Refrigerated Air Dryers. Lower Dew Point is not possible from Refrigerated Dryer as moisture condensed would start freezing on Freon tubes if the lower dew point is tried. This (-) 25°C Dew Point is adequate for most dry air applications and instrument air requirements.
40 CFM Industrial Refrigerated Air Dryer
70,000 Per Piece
1 Piece (MOQ)
Refrigerated Air Dryers are type of compressed air dryer, used to dry compressed air. Compressed air always contains water, coming from the air that is sucked in by the compressor. These dryers are a popular option for cooling compressed air. They use the same operating principle as air conditioning units and refrigerators. They help to dry air by passing it through a refrigerated heat exchanger. The offered Refrigerated Air Dryers are very efficient and safe for use in various industries.
Heatless Air Dryer
Get Price Quote
1 Pieces (MOQ)
Desiccant Air Dryer
45,000 Per Piece
1 Piece (MOQ)
Refrigerated Air Dryer
35,000 - 150,000 Per piece
Refrigerated Air Dryer that we offer is widely acknowledged for effectively removing the water vapors from the compressed air. Manufactured using superior grade material, our Refrigerated Air Dryer is highly accredited for its sturdy construction, low maintenance, and longer operational life. Moreover, our Refrigerated Air Dryer delivers a dew point not lower than approximately -35 °F (2 °C). We make available bulk quantities of Refrigerated Air Dryer at the most competitive rates.
Refrigeration Air Dryer
30,000 Per Piece
1 Piece (MOQ)
0.0
Website
Dryspell Desiccant Compressed Air Dryer
30,000 - 3,400,000 Per Piece
1 Piece (MOQ)
Refrigerated Air Dryer
Get Price Quote
HEAT EXCHANGER WITH MOISTURE SEPARATOR Our Heat Exchanger comprises of Pre cooler, Evaporator and built in Stainless Steel demister moisture separator. Cross flow type Pre cooler (air to air heat exchanger) and evaporator (air to refrigerant heat exchanger) ensure more cross sectional area for flow to make it non-clogging. Heat exchanger is designed to have better turbulence & maximized heat transfer rate. Lesser difference in temperature between Inlet Air & Outlet Air ensures better effectiveness. Piping is completely eliminated and the air passage is non-ferrous. The heat exchanger assembly is encapsulated by PUF Insulation (Eco friendly) to prevent the loss of cooling effect. Non-Cyclic Refrigeration System HOT GAS BY-PASS Value automatically maintains dew point temperature across a wide range of load and ambient conditions without the need for any adjustments. High pressure, high temperature refrigerant vapor is introduced after the expansion value to ensure temperature control. Automatic Condensate Drain Adjustable electronic timer controlled: Pilot operated / direct: compressed air powered Auto drain valve. Positive discharge of heavily contaminated condensate. Ease Of Installation: All dryers are shipped pre-piped and wired, ready to install and operate. Installation is made easy with conveniently located Air and Drain connections. Environmental FS CURTIS DRYERS are designed to have low energy usage, helping to conserve the Earth's Resources and minimize pollution. Refrigerants are with zero ozone depletion factor, and thereby making FS CURTIS dryers' 'OZONE FRIENDLY'.
Air & Gas Dryer
Get Price Quote
Heatless Air Dryers Operating principleIn Heatless Dryers, two vessels filled with desiccant are provided, which cycle automatically, producing Dry air continuously. In these units, wet air enters the bottom of one vessel and passes upwards through the desiccant bed where the moisture is adsorbed. The dry air comes out from the top. A small portion of Dry air is passed downward through the desiccant bed in the second vessel, which is under re-generation. Moisture laden purge air is then vented out to atmosphere. The purge loss is around 7.5% of the total air flow. At preset interval, the vessels changeover automatically, and Dry air is available continuously, without any surges.Simple Design / Easy operationThis is the simplest type of Air Dryer with Activated Alumina / Molecular sieves drying agent. This design is virtually maintenance free, fully automatic, and requires no attention for years. Heatless type dryers do not require any heating for re-generation and therefore are very simple in design and maintenance free.Low Investment / Low operating cost Due to its inherent simple design, investment in this type of dryer is the cheapest and the payback on this investment is very quick. Low temperature operation reduces corrosion in towers and desiccant lasts longer. Power requirement is single phase 220 /110 volts,50 Hz , 60 watts only for solenoid valves operation.
Refrigerated Air Dryer
35,000 Per Piece
Refrigerated Air Dryer
730,000 Per unit
Refrigerated Air Dryer
25,000 - 80,000 Per Piece
1 Piece (MOQ)
Salient Features Compact design Running cost is very low Hot Gas by-pass circuits for partial load Maintains constant pressure dew point Auto drain valve provided for cyclone separator Low pressure.
45 CFM Refrigerator Air Dryer
27,000 Per Piece
1 Piece (MOQ)
0.0
Website
350 CFM Desiccant Dryer
Get Price Quote
1 Unit (MOQ)
Desiccant Heated Air Dryer
80,000 - 1,000,000 Per piece
1 Piece (MOQ)
BEI - 20 AD Refrigerated Air Dryer, 230 V
59,500 - 60,500 Per piece
1 Piece (MOQ)
Heatless Air Dryer
Get Price Quote
Heat less air dryers are used instrumentation and process applications like CNC machines, spray painting, nitrogen generators, laboratories etc. Main Features are Dew point achieved - 40˚C. Compact design, can be mounted on wall. Low power consumption. Light weight, Aluminium construction, Rust free. Specially graded desiccants for optimum performance. Equipped with pre filter & internal post filter. Quality as per ISO 8573.1 class 3. Range from 5 CFM to 1000 CFM.
Heatless Refrigerated Air Dryer
15,000 Per Piece
1 Piece(s) (MOQ)
Post Free Ad
